Skip directly to search Skip directly to A to Z list Skip directly to page options Skip directly to site content

NIOSHTIC-2 Publications Search

Search Results

Painter's helper falls to death from bridge pier.

New Jersey Department of Health and Senior Services
Trenton, NJ: Public Health Services Branch, New Jersey Department of Health and Senior Services, Division of Epidemiology, Environmental, and Occupational Health, Occupational Health Service Occupational Health Surveillance Program, 2008 Dec; :1
A 24 year-old painter's helper fell 140 feet to his death from the supporting pier of a large bridge. The victim was wearing a safety belt, but had not secured his lanyard to a safety line. Background: The victim was employed by a large national bridge maintenance company which painted bridges and installed rigging for scaffolds. The company had been contracted to install a basket lift in preparation for inspection of the bridge by engineers. The lift, suspended on a wire rope by an electric winch, was to carry engineers as they inspected the concrete supporting pier for structural defects. Although hired as a painter's helper, the victim had been asked to help install the lift. With the company for only a week and a half, this was his first day on the job. The top of the supporting pier is located beneath the roadway of the bridge. To reach it, workers must descend through a locked hatchway at the north side of the road surface. By climbing down a permanent ladder with handrails, they emerge onto the northern end of the pier, which is protected by a railing. A six-foot wide walkway leads to the southern end. The walkway has no railing and is only five feet high; most workers must bend over to walk across. The walkway is permanently equipped with a horizontal static safety line, mounted 12 inches in from the edge of the pier. The Incident: At the time of the incident, a four-person crew had installed the rigging for the basket lift at the southern end of the pier. Two members of the crew remained on the road level of the bridge and planned to lower the lift to the top of the pier. The victim and his supervisor descended to the pier through the hatchway; they were to secure the lift once it was lowered to them. After they descended to the pier, the supervisor crossed the walkway to the southern end of the pier, followed by the victim. Both men wore safety belts with the lanyards wrapped around their waists. Contrary to safety procedures, the supervisor did not attach his lanyard to the static safety line but held onto the line with his hand as they crossed the pier. When he reached the other side, he attached his lanyard to a vertical safety rope that had been installed for use by workers in the lift. There were no witnesses to the fall. The victim, who was new to this type of work, also did not attach his lanyard to the horizontal static line. As he crossed the pier, he fell 140 feet to the wet mud below. He was pronounced dead at the scene by emergency medical personnel. The supervisor did not see him fall; he had walked around a bridge pylon which blocked his view.
Hazards; Health-hazards; Mortality-data; Injuries; Traumatic-injuries; Injury-prevention; Accidents; Accident-potential; Accident-prevention; Accident-analysis; Painters; Fall-protection; High-altitudes; Maintenance-workers; Hoisting-equipment; Scaffolds; Ladders; Walking-surfaces; Work-practices; Safety-belts; Safety-equipment; Safety-practices
New Jersey Department of Health and Senior Services, Occupational Health Service, Fatality Assessment & Control Evaluation (FACE) Project, PO Box 360, Trenton NJ 08625-0360
Publication Date
Document Type
Email Address
Funding Type
Cooperative Agreement
Fiscal Year
NTIS Accession No.
NTIS Price
Identifying No.
Source Name
Painter's Helper Falls to Death From Bridge Pier
Performing Organization
New Jersey Department of Health and Senior Services