Special Issue

New Technologies to Prevent Intravascular Catheter-Related Bloodstream Infections

Leonard A. Mermel
Brown University School of Medicine and Rhode Island Hospital, Providence, Rhode Island, USA

Intravascular catheter-related bloodstream infections are an important cause of illness and excess medical cost. In prospective studies, the relative risk (RR) for a catheter-related bloodstream infection is 2 to 855 times higher with central venous catheters than peripheral venous catheters (1-3). Approximately 80,000 catheter-related bloodstream infections occur in U.S. intensive-care units each year, at a cost of $296 million to $2.3 billion (4,5). These infections are associated with 2,400 to 20,000 deaths per year. The focus of this article is on preventive strategies aimed at central venous catheters.

Chlorhexidine-Silver Sulfadiazine-Impregnated Catheters

Catheters impregnated with chlorhexidine-silver sulfadiazine are commercially available. In prospective, randomized studies of catheters left in place for an average of < 11 days (6-14), the incidence of catheter-related bloodstream infections was reduced by using chlorhexidine-silver sulfadiazine-impregnated catheters (RR 0.4, confidence interval [CI] 0.2-0.8)(4). These catheters are cost effective if the incidence of bloodstream infections is greater than 3.3/1000 catheter-days (6) or greater than 1% (15). In addition, if chlorhexidine-silver sulfadiazine-impregnated catheters in place for < 10 days reduce infections from 5.2% to 3%, then for every 300 catheters used, approximately $60,000 would be saved and seven catheter-related bloodstream infections and one death would be prevented (15). Published studies of chlorhexidine-silver sulfadiazine-impregnated catheters were performed with catheters impregnated extraluminally. However, the U.S. Food and Drug Administration (FDA) has recently approved the use of catheters impregnated intraluminally with chlorhexidine, in addition to chlorhexidine-silver sulfadiazine extraluminal impregnation. Use of chlorhexidine-silver sulfadiazine-impregnated catheters has been associated with serious anaphylactoid reactions in Japan (16), and these catheters are not commercially available in that country. One such reaction in the United States has been reported to the FDA (as of April 2000). Resistance to the antiseptic components of this device has not been demonstrated in clinical studies (6). However, in vitro studies of Pseudomonas stutzeri exposed to slowly increasing concentrations of chlorhexidine, in the absence of silver sulfadiazine, have demonstrated the development of resistance to chlorhexidine and associated resistance to several classes of therapeutic antimicrobial agents (17). Although the conditions in these experiments do not simulate clinical practice, the experiments demonstrate the potential for resistance associated with use of these devices.

Minocycline-Rifampin-Impregnated Catheters

Catheters impregnated with minocycline and rifampin are commercially available. In a prospective, randomized clinical trial of catheters in place for an average of 6 to 7 days, minocycline-rifampin-impregnated catheters were associated with lower incidence of infection than chlorhexidine-silver sulfadiazine-impregnated catheters (RR 0.1, CI 0-0.6)(18). The active ingredients of the minocycline-rifampin-impregnated catheters were on the extraluminal and intraluminal surfaces of the device, whereas the active ingredients of the chlorhexidine-silver sulfadiazine-impregnated catheters were only on the extraluminal surface. Therefore, the difference in the incidence of infection may reflect the extent of impregnation on the catheters, in addition to the difference in active ingredients. If minocycline-rifampin-impregnated catheters reduce infections from 5% to 0%, then for every 850 catheters used, approximately $500,000 would be saved (19). Resistance to active antimicrobial components of the minocycline-rifampin-impregnated catheters has not been demonstrated in clinical studies (18,19). However, when these catheters were implanted for 7 to 14 days in laboratory animals and then removed and placed on agar plates injected with Staphylococcus aureus, microbial growth was detected in the zones of inhibition (20); this growth may represent subpopulations of S. aureus with reduced susceptibility to minocycline or rifampin. In additional experiments, minocycline-rifampin-impregnated catheters were implanted in animals for 7 days, after which rifampin-resistant, minocycline-susceptible S. epidermidis was introduced into the insertion site and tunnel tract. In this animal model, the minocycline-rifampin-impregnated catheters were not protective (20). These studies suggest the potential for resistance against the antimicrobial agents used to impregnate these catheters as their clinical use becomes more widespread.

Catheter Hubs Containing Iodinated Alcohol

A catheter hub containing an antiseptic chamber filled with 3% iodinated alcohol is commercially available in Europe but not in the United States. In a prospective, randomized trial of catheters in place for an average of 15 to 16 days, use of a hub with the antiseptic chamber reduced the incidence of infection (RR 0.2, CI 0.1-0.7) (21). A formal cost-benefit analysis has not been published. However, use of this device led to fourfold reduction in the incidence of infections, and the device would most likely be cost-effective when used with central venous catheters in place for approximately 2 weeks. A minute amount of iodine (0.024 mg) is estimated to enter the bloodstream each time the hub containing the antiseptic chamber is punctured (21). However, the currently marketed device has been modified, and entry of iodine into the bloodstream with daily use has not been reported.

Chlorhexidine-Impregnated Sponge Dressings

Use of a commercially available chlorhexidine-impregnated sponge dressing at the insertion site of central venous and arterial catheters led to a threefold reduction in catheter-related bloodstream infections in a recent prospective, randomized study (22).

Nontechnologic Interventions

Several strategies reduce the risk for catheter-related bloodstream infection. In a prospective, randomized study of central venous catheter insertion, use of maximal barrier precautions (large sterile sheet drape; long-sleeved sterile gown; sterile gloves, mask, and hat) resulted in lower incidence of infections, 0.08/1,000 catheter-days, compared with use of minimal precautions (small sterile drape and sterile gloves), 0.5/1,000 catheter-days (23). In another prospective, randomized trial of peripheral catheter insertions, the catheters inserted and managed by a specialized nursing team had a lower incidence of infection than catheters inserted and managed by house officers (odds ratio 0, CI 0-0.6 [24]). In prospective, cohort studies, continuing quality improvement programs aimed at appropriate insertion and maintenance of catheters substantially reduced the incidence of infection (25-29). In a prospective, randomized trial of catheters not used for blood-drawing, tunneling of short-term internal jugular central venous catheters was associated with lower incidence of infection than nontunneling of catheters (RR 0.2, CI 0.1-0.7 [30]).

Some of the nontechnologic interventions aimed at reducing the risk for catheter-related bloodstream infection, such as quality improvement programs, depend on changes in human behavior. Once implemented, whether they remain effective over the long term remains to be seen.

Future Strategies

Greater understanding of the pathogenesis of intravascular-related infections will help prevent such infections. For example, S. aureus binding to the catheter surface in vivo involves fibronectin-specific adhesions (31). Identification of epitopes in the S. aureus fibronectin-binding protein for the generation of adhesion-blocking antibodies (32) may aid in preventing future infections. The development of bacterial biofilms on the surface of foreign bodies involves cell-to-cell signaling by acyl homoserine lactone-based chemical messengers that control bacterial gene expression (33,34). Prevention of microbial growth on the surface of future intravascular catheters may be mediated by inhibitors of these chemical messengers (35).

Dr. Mermel is associate professor of medicine, Brown University School of Medicine; medical director, Department of Infection Control, Rhode Island Hospital, and a special government employee, FDA. He was chief medical resident at St. Louis University Hospitals and infectious disease fellow at the University of Wisconsin Hospitals.

Address for correspondence: Leonard Mermel, Division of Infectious Diseases, Rhode Island Hospital, 593 Eddy St., Providence, RI 02903; Fax: 401-444-8154; e-mail: lmermel@lifespan.org

References

1. Maki DG. Skin as a source of nosocomial infection: directions for future research. Infect Control 1986;7:113-7.
2. Richet H, Hubert B, Nitemberg G, Andremont A, Buu-Hoi A, Ourbak P, et al. Prospective multicenter study of vascular-catheter-related complications and risk factors for positive central-catheter cultures in intensive care unit patients. J Clin Microbiol 1990;28:2520-5.
3. Collignon PJ. Intravascular catheter associated sepsis: a common problem. Med J Aust 1994;161:374-8.
4. Mermel LA. Prevention of intravascular catheter-related infections. Ann Intern Med 2000;132:391-402.
5. Mermel LA. Preventing intravascular catheter-related infections [letter]. Ann Intern Med 2000;133:395.
6. Maki DG Stolz SM, Wheeler S, Mermel LA. Prevention of central venous catheter-related bloodstream infection by use of an antiseptic-impregnated catheter. A randomized, controlled trial. Ann Intern Med 1997;127:257-66.
7. van Heerden PV, Webb SAR, Fong S, Golledges CL, Roberts BL, Thompson WR. Central venous catheters revisited-infection rates and an assessment of the new fibrin analysing system brush. Anaesth Intens Care. 1996;24:330-3.
8. Hannan M, Juste R, Shankar U, Nightingale C, Axadian B, Soni N. Colonization of triple lumen catheters. A study on antiseptic bonded and standard catheters [abstract]. Clin Intensive Care 1996;7:56.
9. Bach A, Schmidt H, Bottiger B, Schrieber B, Bohrer H, Motsch J, et al. Retention of antibacterial activity and bacterial colonization of antiseptic-bonded central venous catheters. J Antimicrob Chemother 1996;37:315-22.
10. Collin GR. Decreased catheter colonization through the use of an antiseptic-impregnated catheter. A continuous quality improvement project. Chest 1999;115:1632-40.
11. George SJ, Vuddamalay P, Boscoe MJ. Antiseptic-impregnated central venous catheters reduce the incidence of bacterial colonization and associated infection in immunocompromised transplant patients. Eur J Anaesthesiol 1997;14:428-31.
12. Pemberton LB, Ross V, Cuddy P, Kremer H, Fessler T, McGurk E. No difference in catheter sepsis between standard and antiseptic central venous catheters. A prospective randomized study. Arch Surg 1996;131:986-9.
13. Ramsay J, Nolte F, Schwarzmann S. Incidence of catheter colonization and catheter related infection with an antiseptic impregnated triple lumen catheter [abstract]. Crit Care Med 1994;22:A115.
14. Logghe C, Van Ossel C, D'Hoore W, Ezzedine H, Wauters G, Haxhe JJ. Evaluation of chlorhexidine and silver-sulfadiazine impregnated central venous catheters for the prevention of bloodstream infection in leukaemic patients: a randomized controlled trial. J Hosp Infect 1997;37:145-56.
15. Veenstra DL, Saint S, Sullivan SD. Cost-effectiveness of antiseptic-impregnated central venous catheters for prevention of catheter-related bloodstream infection. JAMA 1999;282:554-60.
16. Toshiyuki O, Junichiro H, Naomi K, Mikami K. Anaphylactic shock induced by an antiseptic-coated central nervous catheter. Anesthesiology 1997;87:1242-4.
17. Tattawasart U, Maillard J-Y, Furr JR, Russell AD. Development of resistance to chlorhexidine diacetate and cetylpyridimium chloride in Pseudomonas stutzeri and changes in antibiotic susceptibility. J Hosp Infect 1999;42:219-29.
18. Darouich RO, Raad II, Heard SO, Thornby JI, Wenker OC, Garbrielli A, et al. A comparison of two antimicrobial-impregnated central venous catheters. N Engl J Med 1999;340:1-8.
19. Raad I, Darouiche R, Dupuis J, Abi-Said D, Gabrielli A, Hachem R, et al. Central venous catheters coated with minocycline and rifampin for the prevention of catheter-related colonization and bloodstream infection. A randomized, double-blind trial. Ann Intern Med 1997;127:267-74.
20. Sampath L, Tambe S, Modak S. Comparison of the efficacy of antiseptic and antibiotic catheters impregnated on both their luminal and outer surfaces [abstract]. In: Programs and Abstracts of the 39th Interscience Conference on Antimicrobial Agents and Chemotherapy; 1999 Sep 26-29; San Francisco, California. Washington: American Society for Microbiology, 1999.
21. Segura M, Alvarez-Lerma F, Ma Tellado J, Jimenez-Ferreres J, Oms L, Rello J, et al. A clinical trial on the prevention of catheter-related sepsis using a new hub model. Ann Surg 1996;223:363-9.
22. Maki DG, Mermel LA, Kluger D, Narins L, Knasinski V, Parenteau S, et al. The efficacy of a chlorhexidine-impregnated sponge (Biopatch™) for the prevention of intravascular catheter-related infection: a prospective, randomized, controlled, multicenter study. In: Programs and Abstracts of the 40th Interscience Conference on Antimicrobial Agents and Chemotherapy; 2000 Sep 17-20; Toronto, Canada. Washington: American Society for Microbiology, 2000.
23. Raad II, Hohn DC, Gilbreath J, Suleiman N, Hill LA, Bruso PA, et al. Prevention of central venous catheter-related infections by using maximal sterile barrier precautions during insertion. Infect Control Hosp Epidemiol 1994;15:231-8.
24. Soifer NE, Borzak S, Edlin BR, Weinstein RA. Prevention of peripheral venous catheter complications with an intravenous therapy team. A randomized controlled study. Arch Intern Med 1998;158:473-7.
25. Brennan PJ, Hoegg C, Samel C, Skalina D, Barbagallo S, Shulkkn D. Performance improvement in a medical intensive care unit (MICU) resulting from device based surveillance (DSB) from central venous catheter related bloodstream infections (CVC-BSI) [abstract]. Infect Control Hosp Epidemiol 1997;18(5pt 2):20.
26. Armstrong P, Alfieri N, Clowser M, Steinberg RA, Spornitz ME, Runge W, et al. Central line-associated (CLA) surveillance and continuing quality improvement in an intensive care unit (ICU) [abstract]. J Hosp Infect 1998;40(Suppl A):8.1.8.
27. Sherertz RJ, Ely EW, Westbrook DM, Gledhill KS, Streed SA, Kiger B, et al. Education of physicians-in-training can decrease the risk for vascular catheter infection. Ann Intern Med 2000;132:641-8.
28. Eggimann P, Harbarth S, Constantin M-N, Touveneau S, Chevrolet J-C, Pittet D. Impact of a prevention strategy targeted at vascular-access care on incidence of infections acquired in intensive care. Lancet 2000;355:1864-8.
29. Maas A, Flament P, Pardou A, Deplano A, Dramaix M, Struelens MJ. Central venous catheter-related bacteremia in critically ill neonates: risk factors and impact of a prevention programme. J Hosp Infect 1998;40:211-24.
30. Timsit J-F, Sebille V, Farkas J-C, Misset B, Martin J-B, Chevret S, et al. Effect of subcutaneous tunneling on internal jugular catheter-related sepsis in critically ill patients. A prospective randomized multicenter study. JAMA 1996;276:1416-20.
31. Vaudaux P, Pittet D, Haeberli A, Lerch PG, Morganthaler J-J, Proctor RA, et al. Fibronectin is more active than fibrin or fibrinogen in promoting Staphylococcus aureus adherence to inserted intravascular catheters. J Infect Dis 1993;167:633-41.
32. Huesca M, Sun Q, Peralta R, Sauder DN, McGavin MJ. Synthetic peptide immunogens elicit polyclonal and monoclonal antibodies specific for linear epitopes in the D motifs of Staphylococcus aureus fibronectin-binding protein, which are composed of amino acids that are essential for fibronectin binding. Infect Immun 2000;68:1156-63.
33. Davies DG, Parsek MR, Pearson JP, Iglewski BH, Costerton JW, Greenberg EP. The involvement of cell-to-cell signals in the development of a bacterial biofilm. Science 1998;280:295-8.
34. Parsek MR, Val DL, Hanzelka BL, Cronan JE Jr, Greenberg EP. Acyl homoserine-lactone quorum-sensing signal generation. Proc Natl Acad Sci U S A 1999;96:4360-5.
35. Otto M, Sussmuth R, Vuong C, Jung G, Gotz F. Inhibition of virulence factor expression in Staphylococcus aureus by the Staphylococcus epidermidis agr pheromone and derivative. FEBS Lett 1999;450:257-62.

Home | Top of Page | Current Issue | Expedited | Upcoming Issue | Past Issue | EID Search | Contact Us

CDC Home | Search | Health Topics A-Z

This page last reviewed December 08, 2001

Emerging Infectious Diseases Journal
National Center for Infectious Diseases
Centers for Disease Control and Prevention